CarModelProblems.com

1993 Chevrolet Astro Problems & Recalls

Built from official NHTSA complaint and recall data · data through 07/12/2026

High complaint levelIts most-reported problem — Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip — runs 3.4× the fleet median for that category across the 2075 model-years tracked on this site.
135Complaints
5Recalls
10Crashes
4Fires
8Injured
0Deaths

Source: U.S. NHTSA complaint & recall data. Complaints are unverified reports from vehicle owners — a complaint is not a confirmed defect.

Is this problem acknowledged?

The most-reported problem — Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip (25.2% of complaints) — recall and investigation status for this vehicle is currently unavailable.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip complaints here are 3.4× the median for that category across the 2075 model-years tracked on this site.

Complaint categoryReportsOfficial statusReference
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip34 · 25.2%not available
Suspension:front:springs:torsion Bar10 · 7.4%not available
Power Train:automatic Transmission9 · 6.7%not available
Engine And Engine Cooling:engine6 · 4.4%not available
Seat Belts:front:anchorage6 · 4.4%not available
Electrical System:wiring5 · 3.7%not available

Recalled = an NHTSA safety recall covers this category, so a free repair exists. Under investigation = NHTSA has an open probe but no recall yet. Investigation closed = NHTSA examined it and closed the probe — this is not a defect finding; where a closed probe led to a recall we name the campaign. Not available = recall or investigation data could not be confirmed for this vehicle — it is not a “no”. Categories are matched by NHTSA's top-level component. Check your VIN at nhtsa.gov/recalls.

Complaints by component

SUSPENSION:FRONT:SPRINGS:TORSION BAR10 · 7.4%
POWER TRAIN:AUTOMATIC TRANSMISSION9 · 6.7%
ENGINE AND ENGINE COOLING:ENGINE6 · 4.4%
SEAT BELTS:FRONT:ANCHORAGE6 · 4.4%
ELECTRICAL SYSTEM:WIRING5 · 3.7%
SUSPENSION:FRONT5 · 3.7%
POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH5 · 3.7%
VEHICLE SPEED CONTROL4 · 3%
ELECTRICAL SYSTEM:IGNITION4 · 3%

Percentages are the share of the 135 complaints citing each component; one complaint can cite several components. “Unspecified / other” is NHTSA’s own catch-all category — we show it rather than hide it.

Recalls — 5 campaigns

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

NHTSA campaign 06E041000 · 2006 · reported 05/18/2006

A FUEL LEAK CAN OCCUR AT THE VALVE, POSSIBLY RESULTING IN A FIRE. Recall repairs are free at authorized dealers.

PARK-IT: NO  · PARK-OUTSIDE: NO  ·  OVER-THE-AIR FIX: NO

Fuel System, Gasoline

NHTSA campaign 06E043000 · 2006 · reported 05/19/2006

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR. Recall repairs are free at authorized dealers.

PARK-IT: NO  · PARK-OUTSIDE: NO  ·  OVER-THE-AIR FIX: NO

Exterior Lighting

NHTSA campaign 06E049000 · 2006 · reported 05/24/2006

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING. Recall repairs are free at authorized dealers.

PARK-IT: NO  · PARK-OUTSIDE: NO  ·  OVER-THE-AIR FIX: NO

Exterior Lighting

NHTSA campaign 06E026000 · 2006 · reported 03/23/2006

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING. Recall repairs are free at authorized dealers.

PARK-IT: NO  · PARK-OUTSIDE: NO  ·  OVER-THE-AIR FIX: NO

Seats:front Assembly:head Restraint

NHTSA campaign 94V177000 · 1994 · reported 09/14/1994

CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT. Recall repairs are free at authorized dealers.

PARK-IT: NO  · PARK-OUTSIDE: NO  ·  OVER-THE-AIR FIX: NO

Park it Park outside Specimen badges — shown on a recall card only when NHTSA sets the flag. None of the campaigns above carries either flag. Always check your own vehicle by VIN at nhtsa.gov/recalls.

What owners report

“BOTH ABS AND BRAKE LIGHTS STAYED ON. ABS BRAKES WERER NOT WORKING. MANUFACTURER HAS ISSUED A SERVICE BULLETIN ON BRAKING SYSTEM. CONSUMER WAS NOTIFIED BY…”NHTSA complaint 884241 — filed 03/26/2001 · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
“VEHICLE HAS ABS BRAKES. WHEN APPLIED, ABS BRAKING SYSTEM WOULD FAIL TO STOP VEHICLE. TOOK TO DEALERSHIP & MECHANIC PLACED VEHICLE ON HOIST, AND PUSHED…”NHTSA complaint 858337 — filed 03/10/2000 · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
“UPON APPLICATION OF BRAKE PEDAL ABS BRAKE SYSTEM APPEARS TO BE ACTIVATING, CAUSING STEERING PROBLEMS. I CHECKED BRAKE PADS,ROTOR AND CALIPERS. NO FAILURE OR WEAR…”NHTSA complaint 716777 — filed 01/03/2000 · SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Excerpts are shortened and scrubbed of personal details; they are individual, unverified reports.

Complaint trend by year filed

3819952319961219972519983219991420001220017200252003620041201122013

Frequently asked questions

What are the most common problems with the 1993 Chevrolet Astro?

Service brakes, hydraulic:antilock/traction control/electronic limited slip issues are the most-reported category, cited in 34 of 135 NHTSA complaints (25.2%), followed by suspension:front:springs:torsion bar (10), power train:automatic transmission (9), engine and engine cooling:engine (6). Complaints are unverified owner reports.

How many complaints does the 1993 Chevrolet Astro have?

135 complaints were on file with NHTSA as of 07/12/2026. Of those, 10 involved a crash, 4 involved a fire, and 8 reported injuries. No deaths were reported.

Does the 1993 Chevrolet Astro have any recalls?

Yes — 5 NHTSA safety recall campaigns, including campaign 06E041000. Recall repairs are free at authorized dealers. Check your specific vehicle by VIN at nhtsa.gov/recalls.

Has NHTSA acted on the 1993 Chevrolet Astro's reported problems?

Recall or investigation data is partly unavailable for this vehicle right now — check your VIN at nhtsa.gov/recalls for the authoritative answer.

Is a complaint proof of a defect?

No. Complaints are reports submitted by consumers to NHTSA. NHTSA does not verify individual complaints, and a complaint is not proof that a defect exists.

About this data — Complaint figures on this page are consumer reports submitted to the National Highway Traffic Safety Administration (NHTSA), a U.S. government agency. NHTSA does not verify individual complaints; a complaint is not proof that a defect exists, and counts reflect what owners chose to report, not confirmed failure rates. Recall information comes from official NHTSA safety recall campaigns; recall repairs are free at authorized dealers. Always check your specific vehicle by VIN at nhtsa.gov/recalls. CarModelProblems.com is an independent site and is not affiliated with NHTSA or any vehicle manufacturer. Data through 07/12/2026.